Replacing the waste toner box

Order No. WT-200CL

A new waste toner box can print approximately 50,000 A4 or Letter size single-sided pages.

WT Box End Soon message

WT Box End Soon

If the LCD shows WT Box End Soon, it means the waste toner box is near the end of its life. Buy a new waste toner box and have it ready before you get a Replace WT Box message.

Page Top

Replace WT Box message

When the following message appears on the LCD, you need to replace the waste toner box:

Replace WT Box

IMPORTANT

DO NOT reuse the waste toner box.

WARNING

	DO NOT put the waste toner box into a fire. It could explode.
	Be careful not to spill the toner. DO NOT inhale or allow it to get into your eyes.

Turn off the machine. Unplug the power cord from the electrical socket.

Fully open the top cover by lifting up on the handle (1).

IMPORTANT

When the scanner is open, you cannot open the top cover.

Take out all the drum unit and toner cartridge assemblies.

IMPORTANT

•	We recommend that you place the drum unit and toner cartridge assembly on a clean, flat surface with a sheet of disposable paper or cloth underneath it in case you accidentally spill or scatter toner.
•	To prevent damage to the machine from static electricity, DO NOT touch the electrodes shown in the illustration.
•	Handle the toner cartridge carefully. If toner scatters on your hands or clothes, wipe or wash it off with cold water at once.
•	To avoid print quality problems, DO NOT touch the shaded parts shown in the illustrations.

Hold the green handle of the belt unit and lift the belt unit up, then pull it out.

IMPORTANT

To avoid print quality problems, DO NOT touch the shaded parts shown in the illustration.

Remove the orange packing material and discard it.

Note

This step is only necessary when you are replacing the waste toner box for the first time. The orange packing is installed at the factory to protect your machine during shipment. The orange packing is not required for replacement waste toner boxes.

Hold the green handle of the waste toner box and remove the waste toner box from the machine.

CAUTION

Handle the waste toner box carefully in case you accidentally spill or scatter toner. If toner scatters on your hands or clothes, wipe or wash it off with cold water at once.

Note

Discard the used waste toner box according to local regulations, keeping it separate from domestic waste. If you have questions, call your local waste disposal office.

Unpack the new waste toner box and put it in the machine.

Put the belt unit in the machine.

Slide each drum unit and toner cartridge assembly into the machine. Make sure that you match the toner cartridge colour to the same colour label on the machine. Repeat this for all the drum unit and toner cartridge assemblies.

C-Cyan M-Magenta Y-Yellow K-Black

Close the top cover of the machine.

Page Top